After the “first phase” of Renault Logan gained its popularity, the absence of a hatchback body in the line immediately affected. The restyling of Logan coincided with the appearance of the Sandero hatchback, created on its basis, which also differed in the design of the front end; in the second generation, Sandero became as unified as possible with Logan.
All trim levels except the basic ones were equipped with a cabin filter - the first generation has Authentique, the second - Access. However, the technology for self-installation had long been worked out earlier on the first-production Logans, which in principle lacked a cabin filter
The simple procedure for installing the filter in the basic configuration is not difficult to perform. If it is higher than the basic one, then replacing the cabin filter yourself with a Renault Sandero will take at most two minutes.
How to replace the cabin filter on a Renault Sandero?
In dusty conditions in megacities, having an air purifier for the cabin is very important. For comfortable operation of the car, it is necessary to change it on time. Replacing the cabin filter of a Renault Sandero is not difficult and can be done by any car enthusiast without the help of a service station. The article describes how to replace the cabin filter on a Renault Sandero, and there is a video showing this procedure.
The polluted air of large cities contains a large number of different emissions from transport, industrial facilities, and also contains a lot of dust, insects, dirt and harmful impurities.
Thus, during the trip, all people in the car constantly breathe this air. The presence of a filter element in the cabin helps clean incoming air flows from outside from harmful impurities.
Its second function is to protect the radiator of the cooling system from overheating. Only with a clean cleaning element will the stove in the cabin work effectively.
When should you change?
The cabin filter in Renault Sandero, like any other consumable, must be changed regularly. In principle, its replacement does not depend on the mileage of the car, although it is recommended to change it after 15 thousand kilometers.
The period of time after which replacement is needed depends on the conditions in which the vehicle is operated. More frequent replacement is required when operating in a large city or in rural areas with a lot of dust and is expensive.
In summer the air is more polluted than in winter.
To determine the need to replace the cleaning element in the cabin, it should be visually inspected periodically. There are signs by which you can determine whether it needs to be changed:
- The windows in the cabin constantly fog up, regardless of the weather;
- the efficiency of the stove and air conditioner decreases, as the cleaning element becomes dirty and its throughput decreases;
- The air in the cabin contains a lot of dust, and an unpleasant odor appears when the air conditioner operates.
Depending on the type of filter element, it purifies the air not only from contaminants, but also from unpleasant odors. Carbon filters have this property.
Replacement instructions
For comfortable operation of the car, consumables should be changed in a timely manner.
Tools
To perform the procedure you don’t need many tools, just prepare:
- stationery knife or blade;
- flashlight for illumination;
- new consumables;
- vacuum cleaner.
You can install either an original filter or a non-original one.
Consumables
The market offers a wide selection of non-original consumables from companies such as: Delphi, Mann, Bosch, Fram. They are not inferior in quality to the original. To protect against unpleasant odors, install carbon filters.
Stages
Having prepared all the necessary tools, you can begin the replacement procedure. An important feature of Renault Sandero is that the filter may not be installed and you will need to install it yourself. Therefore, two options are possible: installing from scratch and replacing the old one.
Why does dusting occur?
The purity of the air that actually enters the Renault Sandero cabin is ensured, naturally, by such a part as a cabin filter. It is located in a special channel between several fan blades and between the air intake device. So, it turns out that dirty air always passes through a special porous surface, and all the particles, including dirt, remain on it.
In any case, this very porous surface sooner or later becomes clogged with dirt particles. Then the owner of a Renault Sandero car, as well as its Stepway variety, is faced with the task of replacing such a part as the cabin filter directly with a new one. Let us add that dirty air is directed into the deflectors and often accumulates on the inner surface of car windows, seats and even the dashboard. At the same time, an unpleasant odor is formed, which, in turn, comes from the deposits formed on the nozzles on the engine.
A car from France, Renault Sandero, does not always need to be replaced in this case, that is, it often happens that a cabin filter is not provided at all, and, looking for the right solution, you will have to review and re-read a bunch of useful information from people who decided to modify their car on one's own.
How to remove the cabin filter on a Renault Logan: we look at it in detail
There is no need to worry, a solution to this problem was found a long time ago, and it works quite well on Renault Sandero cars, as well as on Stepway versions. The fan is installed in a designated place, which is closed with a plastic plug. Therefore, installing a fan is a fairly simple procedure that can be performed without the help of specialists.
This is interesting: How to install a towbar on a Renault Duster - let’s break it down point by point
How to replace the cabin filter of Renault Sandero Stepway and video of the process
The Renault Sandero Stepway model, accessible to most car enthusiasts, is not particularly burdensome to maintain. In addition, the owner is able to independently carry out simple regulatory procedures. This fully applies to the cabin filter element; it does not even require any tools - only sleight of hand.
When does a Renault Sandero need to replace the cabin filter and what is it for?
Any technically competent car owner will have no problem proving the importance of a cabin air filter in a modern vehicle.
First of all, it is cleaning the air flow that enters the car through ventilation, air conditioning and heating systems.
The filter cassette prevents dust, leaves, insects and other small particles from entering the cabin, which is quite important for people suffering from respiratory abnormalities.
Replacing the Renault Sandero Stepway cabin filter yourself does not look like an extremely complicated process. By completing this routine procedure on time with your own hands, the owner will not only save money on maintenance services, but will also increase the service life and efficiency of the machine’s air conditioning and heating systems.
You may not hear a clear answer to the reasonable question “when should you change the cabin air filter on a Renault Sandero?” This is primarily due to the certain conditions in which the machine operates. It goes without saying that in urban or rural conditions in summer the dust content of the atmosphere is an order of magnitude higher than in winter conditions.
Areas with a humid climate are also not conducive to filter contamination.
If we take average indicators, then it is enough to read the technical documentation from the manufacturer. And he recommends changing the filter element every 15,000 kilometers.
To be absolutely sure that the time has come to change the air filter, it is enough to periodically inspect its condition and pay attention to the following factors:
- regularly fogged interior windows, regardless of weather conditions;
- low efficiency of the operating heater or air conditioner;
- the appearance of a large amount of dust and foreign odors when heating and air conditioning systems are running.
It is important to note here that filter elements based on carbon components purify the air not only of foreign particles, but also of odors, making the microclimate in the cabin neutral. This must be kept in mind when determining the degree of contamination.
What do you need to prepare for work?
As mentioned above, in order to replace the Renault Sandero cabin filter without problems, you do not need a set of tools. It is enough to have a flashlight and a vacuum cleaner or compressor for inflating tires. Naturally, we do not forget about the air filter itself, which can be purchased both from official distributors and on the car market. The first option, as you understand, is more preferable. Recommended list of typical cabin air filters for use on Renault Sandero Stepway:
- Mann CU 1829;
- Corteco 80000074;
- Filtron K1152;
- Nissan 27891-AX010;
- Jakobs autoteile J1 341 015;
- Valeo 698 753.
For those who are sensitive to foreign odors, we recommend carbon filters :
- Eolo 2561;
- Good Will AG 136CFC;
- Delphi TSP0325178C.
The first category of products is, depending on the manufacturer, slightly cheaper than products based on activated carbon. On average, the price range ranges from 400 to 1300 rubles.
How to replace an old cabin filter on a Renault Sandero Stepway and video of the workflow
When everything is ready, it is important to determine the location of the air filter. You should look for it on the passenger side under the glove compartment on the left side. Now you need to proceed according to the following scheme:
- Take a comfortable position and pull out the locking latch.
- First pull out the lower part of the filter element and then remove it completely.
- Clean the installation area using a vacuum cleaner or tire inflator.
- Squeeze the new air filter along the edges and install it in place starting from its top and ending with the bottom until the latch clicks.
After studying the video on replacing the cabin filter on a Renault Sandero Stepway car, you can repeat the entire process yourself in 15-20 minutes. It is quite simple to check the correct installation - turn on the airflow to maximum and check that there is no air leakage on the joining planes.
In order to extend the service life of the cabin air filter, experienced motorists advise additionally installing an under-hood filter element. It is mounted on the air intake grille using clips and, judging by reviews, it effectively prevents leaves from getting into the air duct. However, some people don’t particularly care and use regular tights for the same purpose.
We do the work with our own hands
Numerous owners of Renault Sandero cars from France, including the Stepway version, as well as the manufacturer recommend that if the filter is replaced, then use the Good Will AG136CFC model. This particular consumable is made from a porous material and has an original carbon coating in its structure, which, as everyone knows, makes cleaning deeper.
When replacing, you only need a vacuum cleaner and a handy sharp knife to clean the cavity. I must say right away that it will be inconvenient to work. The plug is located below the glove compartment, so you can only work with it in a lying position. So, this plug is a black rectangle made of plastic, it is located under the glove compartment a little to the right. The plug must be cut strictly along the contour, which is indicated by clear convex lines. It needs to be cut in 2 stages. It is best to start from the middle, where the so-called center of the rectangle is located. After this, a square is cut out at the bottom, which allows you to avoid damaging the rather soft plastic and not touching the car wiring.
After this, when the cavity is open, you need to vacuum everything, after which you need to install the consumables. The filter housing is always compressed to the maximum parallel to its folds and carefully inserted into the window along the guides
Here, on the advice of experts, it is extremely important to consistently start exclusively from the top corner, otherwise the part simply will not fall into place. But the lower part is a kind of latch, and therefore, if you hear a characteristic click, then the work is considered completed
Replacing the cabin filter Renault Sandero Stepway
All car owners, including the Renault line, periodically face the fact that an unpleasant odor appears from the heater deflectors. This usually happens almost immediately after turning on the fan.
It happens that this does not happen immediately, but only during long trips, but it invariably worsens in cold weather. This increases the amount of dust in the cabin. This problem is directly related to the fact that the cabin filter of the Renault Sandero Stepway becomes dirty.
In this case, it is necessary to dismantle the old consumable and install a new one.
Causes of dust
Over time, the filter surface becomes clogged, especially in summer and spring/autumn. This is due to the fact that there is the greatest amount of dust and dirt around the car. In spring, pollen from flowering plants is added to this. Particles from dirty air in the cabin settle on the windows, seats and panels of the car. It also accumulates in large quantities in the deflectors, which, when moisture gets in, leads to the formation of a large number of bacteria - a source of unpleasant odor. In this case, the Renault Sandero Stepway cabin filter needs to be replaced.
Unfortunately, some models do not have this element. But this problem can be solved quite simply - for this purpose, the Renault Sandero Stepway has a special niche closed with a plastic plug.
Self-installation
The manufacturer recommends using the GoodWill AG136CFC model as a replacement.
This consumable is made of a porous material of sufficient porosity so as not to reduce the speed of the air flow and at the same time retain particles of dust and dirt in the air.
In addition, this part has a special carbon coating that can absorb smaller particles, thereby slightly reducing the concentration of exhaust gases from the environment and producing better cleaning.
Replacement options:
- Mann CU 1829
- Corteco 80000074
- Filtron K1152
- Nissan 27891-AX010
- Jakobs autoteile J1 341 015
- Valeo 698 753
Carbon filters:
- Eolo 2561
- Good Will AG 136CFC
- Delphi TSP0325178C
The job of replacing the filter is quite simple and can be done independently. Some difficulties may be associated with a low position, so some of the work may have to be done reclining. But as a result, you will be able to enjoy clean air inside your car for a long time.
We do all the work ourselves
The French automaker and other car enthusiasts insist that the best replacement option for the Renault Sandero is the Good Will AG136CFC air barrier. It is represented by an “accordion” made of specialized paper that has sufficient porosity. It contains carbon spraying. This fact makes it possible to increase the degree of air purification and disinfect it. This cabin filter is popular among consumers.
To install a new consumable, use a knife with a sharp blade and a vacuum cleaner. With its help, dirt is sucked out of the cavity.
During operation, some inconveniences arise: placing the plug under the glove compartment in the area of the front passenger seat makes it necessary to perform work while lying down.
The plug looks like a solid block of plastic, which has a rectangular geometry and is located at the bottom of the glove compartment on the right side. It is cut along the perimeter, which is indicated by convex lines stretched along the contour of the future hole. This procedure is performed in two steps. The starting point of cutting is the conditional center of the rectangle. Afterwards, a square-shaped window is made at the bottom, which makes it possible to avoid damage to the wiring and not touch fragile plastic. Then, after vacuuming the channel, you should replace the consumables or install it in its original place. To do this, the body is compressed to the maximum from the sides and carefully inserted according to the guides
In this case, it is very important to enter the upper corner first to avoid distortions when installing the consumable. The lower part is a kind of latch that will make a characteristic click, which will mean the end of the installation process
How to replace the cabin filter in Renault Sandero
The Sandero cabin filter allows you to efficiently clean the outside air entering the car interior. Correctly selected cabin filter:
- effectively traps dust particles;
- eliminates unpleasant odors;
- partially captures toxic elements.
Considering that the air on the roads is quite dirty, the car interior cannot be left without the proper level of filtration.
The reason is that particles and odors entering the limited interior space along with the outside air may well cause not only a deterioration in comfort, but also poor health of the driver and passengers.
For this reason, the cabin filter needs to be changed regularly. Read more in our article.
When and why it is necessary to replace the Renault Sandero cabin filter
For Renault Sandero, it is recommended to change the cabin filter no later than after 30 thousand kilometers. However, replacement may be required sooner if:
- the performance of the interior ventilation system has decreased (air does not blow well from the air ducts even at maximum fan speed);
- when the ventilation was turned on, an unpleasant odor appeared from the air ducts;
- The windows in the cabin began to sweat a lot from the inside (turning on the air conditioner or heater does not solve the problem or only partially solves it).
- the car is operated in a metropolis or is located in conditions of heavy dust/air pollution (for example, frequent driving on dirt or country roads).
In such cases, the cabin filter on Renault Sandero must be replaced after 15-20 thousand km. mileage or every 6-12 months (depending on the intensity of use of the car, individual conditions, and also taking into account the appearance of the above-mentioned signs of contamination of the cabin filter).
Which Sandero cabin filter is better to choose?
Today, in car dealerships, sellers strongly recommend installing a carbon cabin filter instead of the usual anti-dust cabin filter. The main advantage is not only filtering the air from small particles, but also eliminating odors.
The main difference between such a cabin filter (air conditioner filter) is that an absorbent material (carbon) is integrated into the standard filter element (actually paper). At the same time, the coal is additionally treated with special chemicals to combat odors.
It is important to understand that a truly high-quality carbon filter:
- costs significantly more than a regular anti-dust one;
- such a filter gets dirty faster (throughput decreases);
We also add that today there are a large number of carbon filters on the market at an affordable price (20-25% more expensive than conventional dust filters). However, in practice they are not much different from simple filters, since they weakly neutralize odors.
It turns out that the overpayment is not justified. Moreover, such a filter will become dirty faster and will require replacement earlier due to the presence of carbon impregnation. In turn, a truly high-quality and effective carbon cabin filter will cost significantly more than its conventional anti-dust counterpart.
We also add that the cabin filter can be installed on the Sandero either original or an analogue one. Among non-original solutions, you can pay attention to filters from Mann, Bosch, Delphi, etc. Such filters are no worse in quality than original solutions; you can also choose a carbon filter element that is acceptable in quality and price.
What tools are needed
Replacing the cabin filter is not difficult and can be done with your own hands in a regular garage. In this case, it is necessary to prepare some tools, as well as take into account certain nuances as part of the filter replacement procedure.
To replace the Sandero cabin filter, you will need to prepare:
- blade or stationery knife;
- flashlight or lamp for illumination;
- household or car vacuum cleaner;
It is also important to choose the right new filter for the cabin strictly according to the car model. It is recommended to separately study the catalogs of filter manufacturers. It should be remembered that during installation it is extremely undesirable to deform the filter (break, cut, bend, make cuts in the filter housing, etc.).
For this reason, the filter must fit exactly and fit freely into the compartment. This is only possible with the correct and accurate selection of the “salon” according to the make, model and year of manufacture of the car.
Replacing the cabin filter Sandero
On the Sandero model, replacing the cabin filter may be necessary even on a new car, since such a filter may sometimes not be installed from the factory. Also, replacing the cabin filter is necessary if the already installed filter is dirty.
In any case, if you are installing for the first time or replacing an old filter element, the steps are slightly different. If there is no filter on the car, then you can find a “blind” plug (the plug is located to the left of the glove compartment at the bottom) that needs to be cut out. To do this, do the following:
- the plug is cut along the contour with a stationery knife, while the lower part of the strip is difficult to cut (the plastic is 2mm thick);
- Having cut off the bar, the notches are removed along the contour with a blade;
- then a cabin filter compressed at the edges is inserted into the hole;
Please note that the cut-out plug is smaller in size than the filter element itself. To place the filter in the finished hole, the filter must first be compressed on both sides during installation. Also, you need to insert the upper part of the filter first, and then the lower one, until the locking latch works.
To replace the old filter, do the following:
- sit in the front passenger seat;
- pull out the filter latch by pressing the latch;
- remove the old filter (first the upper and then the lower part);
- Afterwards you will need to clean the filter compartment with a vacuum cleaner;
- You can also blow dust out of the compartment with a compressor;
- The new filter is carefully squeezed around the edges and inserted from the top (first top, then bottom) until the latch clicks into place.
As you can see, on Renault Sandero, replacing the cabin filter is done quickly if the filter was already installed before.
If there is a plug, you should be prepared for the fact that such a plug will have to be cut out to gain access to the filter installation compartment.
At the same time, the procedure for cutting out the plug is simple and will allow you to independently replace the cabin filter in just a few minutes.
Refinement of the cooling system of the Lada Kalina car
Considering the fact that this problem is not uncommon for Kalina owners, we can assume that this is a miscalculation of Tolyatti engineers. The owner will have to correct this development inaccuracy.
- Drain the coolant.
- We dismantle and install the plug on the wide pipe, which is connected to the bottom of the expansion tank.
- We install a tee in the lower hose of the stove.
- We install a hose of suitable size, which is connected at one end to the tee, and at the other to the bottom of the expansion tank.
- We install a plug in the return line of the throttle valve heating, and in its place we install an additional hose.
- In the upper part of the expansion tank, you need to install an additional fitting, to which you need to attach a pipe for heating the throttle valve. There is also an option that does not require cutting in an additional fitting. To do this, you need to connect the new line to the upper pipe of the expansion tank using a tee.
- Fill the coolant a little above the maximum mark, start the engine and warm it up until the fan turns on.
- We expel air from the system, pushing through all the lines, and, if necessary, add coolant to the level.
This modification option will prevent the formation of an air lock, and if air gets in during scheduled repairs, removing it will not be difficult. After such a modernization, a slight negative effect is possible in the form of a long warm-up of the engine. But the undoubted advantages will be a well-heating stove and the absence of air locks.
When to change, what interior to install
According to the technical maintenance regulations, the cabin filter on Renault Sandero 1 must be replaced at least once a year. Or when undergoing scheduled maintenance, which occurs every 15 thousand kilometers.
However, when used on Russian roads, within the period specified in the regulations, the cabin filter becomes quite clogged and ceases to perform its functions. Therefore, to ensure normal filtration, owners recommend cutting the time frame for replacing the cabin filter by half.
The ideal option is to change the cabin filter of Renault Sandero I twice a year, once during the winter season, and once before the summer season. In the spring and summer, it is better to install coal, as it copes more effectively with various allergens and unpleasant odors. And in autumn and winter, ordinary dust is enough.
Although the service book indicates specific terms for replacing the filter element, it is often recommended to carry out the replacement earlier, that is, not according to regulations, but as needed. The basis for replacement are signs of filter contamination:
- When the car is used in the summer on dusty road sections, the filter element becomes much more clogged with fine dust, as a result of which replacement may be required earlier.
- With frequent idle time in traffic jams, the element becomes clogged with small particles of exhaust soot, as a result of which it may appear relatively clean in appearance, but at the same time the surface acquires a gray color, indicating severe contamination, and permeability is reduced to almost zero.
- In the fall, leaves can get into the air ducts - even a small amount can become a breeding ground for millions of bacteria that cause an unpleasant odor. It is quite difficult to get rid of it; you will need not only replacing the filter element, but also completely cleaning the box.
- Increased air humidity in the cabin (window fogging).
- Reduced ventilation and heating system power.
- Noise appears when ventilation is turned on to maximum.
Suitable sizes
When choosing a filter element, owners do not always use products recommended by the car manufacturer. Everyone has their own reasons for this, some say that the original is unreasonably expensive. Some people in the region sell only analogues. Therefore, there is a need to know the dimensions by which a selection can subsequently be made:
- Height: 42 mm
- Width: 182 mm
- Length: 207 mm
As a rule, sometimes analogues for Renault Sandero 1 can be a few millimeters larger or smaller than the original, there is nothing wrong with that. And if the difference is measured in centimeters, then of course it’s worth looking for another option.
Selecting an original cabin filter
The manufacturer recommends using exclusively original consumables, which, in general, is not surprising. They themselves are of good quality and are widely available in car dealerships, but their price may seem overpriced to many car owners.
Regardless of the configuration, on all first-generation Renault Sanderos, the manufacturer recommends installing a cabin air filter with article number 272772835R (dust) or 272775374R (carbon). They are also known under other articles, there are no differences in them, and they are interchangeable:
- 272776865R
- 7701059997
- 7701062227
- 7711426872
- 8201055422
- 8201153808
- 8201370532
- 8671018403
It is worth noting that sometimes consumables and other spare parts may be supplied to dealerships under different part numbers. Which can sometimes confuse those who want to purchase an original product.
When choosing between a dust and carbon product, car owners are advised to use a carbon filter element. This filter is more expensive, but it cleans the air much better.
It is easy to distinguish - the paper filter accordion is impregnated with a carbon composition, and therefore has a dark gray color. The filter cleans the air flow from dust, fine dirt, germs, bacteria and enhances the protection of your lungs.
Which analogues to choose
In addition to simple cabin filters, there are also carbon filters that filter the air more effectively, but they are more expensive. The advantage of coal SF is that it does not allow foreign odors coming from the road (street) to penetrate into the car interior.
But this filter element also has a drawback - air does not pass through it well. GodWill and Corteco carbon filters are of fairly high quality and are a good replacement for the original.
However, in some retail outlets the price of the original Renault Sandero 1 cabin filter may be greatly inflated. In this case, it makes sense to purchase a non-original consumable item. In particular, cabin filters are considered quite popular:
Conventional dust cabin filters
- MANN-FILTER CU1829 – high-tech consumables from a well-known manufacturer
- FRAM CF9691 – popular brand, good fine cleaning
- KNECHT/MAHLE LA 230 – considered the best on the market, but the price is correspondingly high
Carbon cabin filters
- MANN-FILTER CUK1829 – high-quality and thick carbon coating
- FRAM CFA9691 – activated carbon
- KNECHT/MAHLE LAK 230 – high quality, above average price
It makes sense to take a closer look at the products of other companies - they also specialize in the production of high-quality consumables for passenger cars:
- Corteco
- Filtron
- SCT
- Sakura
- GoodWill
- JS Asakashi
- Champion
- Zekkert
- Masuma
- BIG Filter
- Nipparts
- Purflux
- Nevsky Filter nf
It is quite possible that sellers may recommend replacing the Sandero I cabin filter with non-original, cheap substitutes with a much smaller thickness. They are not worth buying, since their filtering characteristics are unlikely to be at the proper level.
